South Dakota Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the South Dakota Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the South Dakota Driver Licensing Program uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in South Dakota.

Question 1 of 20

A "smooth bore" tank has:

No internal divisions
Internal baffles
Compartments
Reinforcement rings

Correct. A smooth-bore tank has no internal divisions or baffles. Surge is dramatic; brake gently to avoid being pushed forward by the load.

Question 2 of 20

A "tank vehicle" requiring an N endorsement is generally defined as:

Any commercial vehicle
A vehicle used to transport liquid or gaseous materials in a tank with rated capacity of 1,000 gallons or more, individual tanks of 119+ gallons
Only fuel trucks
Only vehicles over 80,000 lbs

Correct. The N endorsement is required for any commercial vehicle hauling liquid or gas in a permanently mounted tank or portable tank with rated capacity of 1,000+ gallons (and individual tanks of 119+ gallons).

Question 3 of 20

A "bottom-loaded" tank:

Is loaded through bottom valves to reduce vapor and static
Is loaded only at the top
Carries cargo at the bottom only
Has no top vents

Correct. Bottom-loading uses sealed bottom-loading equipment with vapor recovery, reducing static and vapor escape compared to splash-loading from the top.

Question 4 of 20

A "baffled" tank has:

Walls with holes that slow surge but allow flow
No walls
Only one compartment
Outside reinforcement

Correct. Baffled tanks have internal bulkheads with holes — they slow surge but still allow product to flow through during loading and unloading.

Question 5 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

Question 6 of 20

A pressure-relief device that vents during transit:

Is a normal occurrence
Is a serious malfunction or over-fill — stop and investigate
Means the tank is empty
Means the load is cold

Correct. Continuous venting indicates over-pressure (often from over-fill or sun heating an over-filled tank). Stop and investigate; do not continue with a venting tank.

Question 7 of 20

Side-to-side surge is most likely to cause:

Improved fuel economy
Rollover, especially on curves and in evasive maneuvers
No effect
Better braking

Correct. Side-to-side surge can amplify side-loading forces, contributing to rollover on curves and exit ramps.

Question 8 of 20

Compartmented tanks have:

Liquid-tight bulkheads dividing the tank into separate sections
No divisions
Smooth interior
Only baffles

Correct. Compartmented tanks have liquid-tight bulkheads. Each compartment is loaded separately, allowing different products in one trailer.

Question 9 of 20

A loaded tanker on a curve is most likely to:

Roll over because surge plus high CG amplifies side forces
Skid in a straight line
Brake faster
Steer easier

Correct. Side surge plus high CG creates a tipping moment well above what a flat-bed of equal weight produces. Speed reduction in advance is the only safe answer.

Question 10 of 20

When you discover a leak in a cargo tank carrying flammable liquid:

Continue to the destination
Stop in a safe location, secure the area, contact emergency response and the carrier — never transfer cargo on the road
Try to drive around the leak
Pour water on it

Correct. A leaking flammable cargo tank is a major incident — secure the area, evacuate per the ERG, contact emergency services. Never attempt roadside cargo transfer.

Question 11 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

Question 12 of 20

Vapor recovery during loading:

Is used at terminals to capture flammable vapors
Replaces the cargo
Is forbidden
Is used only at night

Correct. Vapor recovery captures flammable vapors displaced as product is loaded, returning them to storage. Required at most modern fuel terminals.

Question 13 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 14 of 20

Outage requirements:

Vary by liquid because of differing thermal expansion rates
Are always 1 percent
Do not exist
Are only for water

Correct. Outage requirements differ by product. Gasoline expands more than diesel, ethanol expands differently, etc. Check the shipping paper or product specifications.

Question 15 of 20

When you drive a tanker on slippery roads, you should:

Drive faster
Reduce speed substantially and increase following distance
Use only the trailer brake
Maintain normal speed

Correct. Reduce speed by at least one-third on wet roads, by half on snow. Liquid loads make recovery from a skid much harder.

Question 16 of 20

Loading dock procedure for cargo tanks of flammable liquid:

Set parking brake, chock wheels, shut off engine, ground and bond, monitor loading, follow loading-rack procedures
Leave the engine running
Skip the chocks
Smoke nearby

Correct. Standard loading-rack procedure: brake set, chocks in, engine off, bond and ground, monitor loading, follow rack-specific procedures (vapor recovery, load arms, etc.).

Question 17 of 20

Carrying a smooth-bore tank up a ramp or off a curb:

Causes minimal surge
Can produce strong front-to-back surge that affects throttle and traction
Has no effect
Improves traction

Correct. Climbing causes the load to surge backward and then forward as you level off — affecting throttle response, traction, and braking.

Question 18 of 20

The driver should plan extra time for:

Acceleration, braking, and turning a fully loaded tanker
Lunch
Sleep only
Refueling only

Correct. A loaded tanker accelerates slower, brakes longer, and turns wider. Plan your trip and reactions accordingly.

Question 19 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 20 of 20

In the event of a fire on a tanker:

Pull off the road, away from buildings, get out, call 911, and use the ERG to identify the response
Continue to deliver
Pour water on a fuel fire
Drive faster to put out the wind

Correct. Pull to a safe area, away from buildings and people. Get out, call 911, and consult the ERG. Some tank fires (e.g., water on flammable liquid) make matters worse.

About the South Dakota Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The South Dakota Driver Licensing Program follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all South Dakota CDL practice tests.