South Carolina Hazmat CDL Practice Test

This is a free 20-question practice test for the Hazmat portion of the South Carolina Commercial Driver's License knowledge exam. Questions are pulled from a pool of 68 drawn from the AAMVA CDL Manual, which is the source document the South Carolina Department of Motor Vehicles uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in South Carolina.

Question 1 of 20

Placards must be displayed on:

One side
Two sides
Three sides
All four sides of the vehicle

Correct. Placards are displayed on all four sides of the vehicle — front, back, and both sides.

Question 2 of 20

Hazardous materials are products that:

Are heavier than normal cargo
Pose a risk to health, safety, or property during transportation
Can only be hauled at night
Require a special trailer color

Correct. Hazardous materials (hazmat) are products that pose a risk to health, safety, or property during transportation. Hazmat regulations are codified in 49 CFR.

Question 3 of 20

Inhalation hazard placards (Division 6.1 PIH or Division 2.3) require:

Smaller placards
Subsidiary "INHALATION HAZARD" placards in addition to the primary placard
No placards
Only one placard

Correct. PIH (Poison Inhalation Hazard) materials require a primary hazard-class placard plus an "INHALATION HAZARD" subsidiary placard.

Question 4 of 20

A hazmat driver must complete which special training?

General awareness, function-specific, safety, security awareness, and in-depth security if a security plan is required
Forklift training
Basic first aid only
Defensive driving only

Correct. PHMSA requires general awareness, function-specific, safety, security awareness, and in-depth security training (when a security plan applies). Carriers document and re-train every three years.

Question 5 of 20

When in the cab with the engine running, the hazmat shipping paper must be:

In the trailer
Within the driver's reach — clipped on the driver's door clip or on the driver's seat
In the glove compartment
In the trunk

Correct. When in the seat with the engine running, keep shipping papers within reach (driver-side door clip or on the seat). When out of the vehicle, leave on the seat or in the door pouch.

Question 6 of 20

You discover a leak in a Class 3 (flammable liquid) shipment. You should:

Continue driving until you find a safe place
Stop, secure the area, notify emergency services, do not transfer cargo on the road, do not move the vehicle further than necessary
Drive faster to deliver the load
Open the placards

Correct. Stop in a safe location, secure the area, call 911, and notify your dispatcher. Do not transfer cargo by the side of the road.

Question 7 of 20

A hazmat carrier with hazmat cargo must conduct security awareness training:

Once at hire
Once every 3 years for each driver
Annually
Never

Correct. PHMSA requires re-training every three years, including security awareness and the carrier's in-depth security plan if applicable.

Question 8 of 20

Placards are required when:

Any amount of a Table 1 material is loaded, or 1,001+ lbs total of any combination of Table 2 materials
Any cargo is loaded
Only flammables are loaded
Only at the driver's discretion

Correct. Table 1 materials always require placards (any amount). Table 2 materials require placards when 1,001 pounds or more of any combination is loaded.

Question 9 of 20

A driver's responsibilities for hazmat include:

Refusing to accept improperly marked, labeled, or leaking shipments; placarding the vehicle; following routes; carrying the shipping paper; responding to incidents
Only signing the bill of lading
Only delivering on time
Only refueling

Correct. The driver verifies the shipment, placards if required, carries the documentation, follows routes and parking rules, and handles incidents per training.

Question 10 of 20

When loading hazmat that requires segregation, the driver must:

Refuse to mix incompatible materials in the same vehicle, per the segregation table
Mix them anyway
Load whatever fits
Stack on top

Correct. The segregation table in 49 CFR §177.848 lists which classes cannot be loaded together. Refusing improperly mixed loads is the driver's responsibility.

Question 11 of 20

A driver of a hazmat-loaded vehicle must check the tires:

Once before the trip
At the start of the trip and every time the vehicle is parked
Only at fueling
Never

Correct. Hazmat drivers must check tires at the beginning and again each time the vehicle is parked. A flat or smoking tire must be addressed before continuing.

Question 12 of 20

When you place placards on a vehicle, the placard ID number (when applicable) must:

Be displayed on each side and end of bulk packagings or on placards or orange panels
Not be shown
Be in red ink only
Be a phone number

Correct. Bulk packagings and certain shipments require the four-digit UN/NA number on each side and end of the package, on the placard, or on an orange panel.

Question 13 of 20

Where can a hazmat-placarded vehicle never be parked?

On private property
Within 5 feet of the traveled portion of a roadway, except briefly for vehicle operation
Anywhere
At a truck stop

Correct. Never park within 5 feet of the traveled portion of a road. Avoid populated areas, near open fires, and near places where people congregate.

Question 14 of 20

Placards must be at least how many inches on each side?

10.75 inches (273 mm)
5 inches
15 inches
20 inches

Correct. Placards are diamond-shaped, at least 250 mm (about 10.75 inches) on each side.

Question 15 of 20

A vehicle that has been transporting hazmat may need to be:

Decontaminated and re-placarded as required after unloading
Painted
Sold
Inspected by USCG

Correct. After unloading, the vehicle may need decontamination depending on the cargo. Placards may need to be removed unless residue still requires them.

Question 16 of 20

Class 1.1, 1.2, or 1.3 explosives must be parked:

Anywhere
In an attended location with a qualified person within 100 feet, awake and able to see the vehicle
At a school
At a gas station

Correct. Division 1.1, 1.2, and 1.3 explosives, and Division 2.3 or 6.1 PIH cargo, must have an attended-vehicle (qualified person within 100 feet, awake, able to see the vehicle).

Question 17 of 20

Hazard Class 8 is:

Flammable solids
Corrosives
Radioactive
Gases

Correct. Class 8 is corrosive materials — sulfuric acid, sodium hydroxide, hydrochloric acid, etc.

Question 18 of 20

You may use a flame to check for hazmat leaks:

When you have a respirator
Never — never use any flame near hazmat
Only at night
Only with permission

Correct. Never use a flame to check anything near hazmat. Use a flashlight or other intrinsically safe light.

Question 19 of 20

When a hazmat shipment crosses international borders:

Documentation may need to comply with both US and Canadian/Mexican regulations
No special documentation is needed
Only US regulations apply
Only foreign regulations apply

Correct. Cross-border hazmat may require documentation in compliance with both jurisdictions, plus customs paperwork.

Question 20 of 20

When you transport Division 1.1 or 1.2 explosives, you must have a written route plan:

No, never
Yes — required for these explosives
Only on weekends
Only across state lines

Correct. A written route plan is required for transporting Division 1.1 or 1.2 explosives. The driver must follow it unless there is an emergency.

About the South Carolina Hazmat exam

Most states administer 30 Hazmat questions and require 80% to pass. The exam covers hazard classes, the shipping paper, placards and labels, loading and unloading, driving and parking rules, emergency response, and the Emergency Response Guidebook (ERG).

The South Carolina Department of Motor Vehicles follows the federal CDL standards established by FMCSA. To earn the Hazmat credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Hazmat question bank or browse all South Carolina CDL practice tests.