Pennsylvania Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Pennsylvania Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Pennsylvania Department of Transportation Driver Licensing uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Pennsylvania.

Question 1 of 20

A "tank vehicle" requiring an N endorsement is generally defined as:

Any commercial vehicle
A vehicle used to transport liquid or gaseous materials in a tank with rated capacity of 1,000 gallons or more, individual tanks of 119+ gallons
Only fuel trucks
Only vehicles over 80,000 lbs

Correct. The N endorsement is required for any commercial vehicle hauling liquid or gas in a permanently mounted tank or portable tank with rated capacity of 1,000+ gallons (and individual tanks of 119+ gallons).

Question 2 of 20

A "baffled" tank has:

Walls with holes that slow surge but allow flow
No walls
Only one compartment
Outside reinforcement

Correct. Baffled tanks have internal bulkheads with holes — they slow surge but still allow product to flow through during loading and unloading.

Question 3 of 20

Pressure relief devices on cargo tanks are designed to:

Open if pressure inside exceeds safe limits, releasing product or vapor before the tank ruptures
Increase pressure
Be tightened down
Stay closed at all times

Correct. Pressure relief valves open at a set pressure to prevent tank rupture. Tampering with them is illegal and dangerous.

Question 4 of 20

A tank with multiple compartments may have:

Different products in each compartment, requiring careful unloading sequence and verification
Only one product
No internal walls
No discharge

Correct. Compartmented tanks (common on fuel-delivery trucks) carry different grades or different products. Verify the destination tank before opening any discharge valve.

Question 5 of 20

Tank specification "MC-306" or "DOT-406" generally refers to:

Cargo tanks designed for non-pressure flammable and combustible liquids (e.g., gasoline, diesel)
High-pressure gases
Cryogenic liquids
Hazardous solids

Correct. MC-306 (older) and DOT-406 (current) are non-pressure cargo tanks for flammable and combustible liquids — typical fuel tankers.

Question 6 of 20

When you discover a leak in a cargo tank carrying flammable liquid:

Continue to the destination
Stop in a safe location, secure the area, contact emergency response and the carrier — never transfer cargo on the road
Try to drive around the leak
Pour water on it

Correct. A leaking flammable cargo tank is a major incident — secure the area, evacuate per the ERG, contact emergency services. Never attempt roadside cargo transfer.

Question 7 of 20

When driving a tanker through a sharp bend at the recommended speed for cars:

You are likely to roll over
You are safe
You will accelerate
Brakes engage automatically

Correct. Tanker rollovers regularly happen at posted "car" curve speeds. Slow well below posted speeds in a loaded tanker.

Question 8 of 20

Vapor recovery during loading:

Is used at terminals to capture flammable vapors
Replaces the cargo
Is forbidden
Is used only at night

Correct. Vapor recovery captures flammable vapors displaced as product is loaded, returning them to storage. Required at most modern fuel terminals.

Question 9 of 20

Outage refers to:

Empty space left at the top of a tank to allow liquid expansion
The brake-out system
A power failure
A driver shortage

Correct. Outage is the empty space left at the top of a tank to allow liquid to expand as it warms. Different liquids require different outage percentages.

Question 10 of 20

You should never load a tank completely full because:

It is illegal in all states
Liquids expand when warmed and need outage; over-filling can rupture the tank
Trucks won't move
It saves no time

Correct. Liquids expand with temperature. Without outage, a warming load can over-pressurize and rupture the tank.

Question 11 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

Question 12 of 20

When braking a partially filled smooth-bore tank, you should:

Brake hard at the last minute
Brake gently and start braking earlier than usual to compensate for surge
Use only the trailer hand valve
Pump the brakes

Correct. In smooth-bore tanks, surge is severe. Brake gently and earlier than you would in a dry-van trailer to avoid being pushed forward.

Question 13 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 14 of 20

Tankers have a high center of gravity because:

The driver sits high
The load is in a tall, narrow tank
The cargo is light
The cab is wide

Correct. A tank carries its load high above the road. The center of gravity is much higher than for a flatbed of the same weight, increasing rollover risk.

Question 15 of 20

Bonding and grounding during product transfer:

Equalizes electrical potential between the tank and receiving container, preventing static-spark ignition
Charges the battery
Cools the load
Speeds delivery

Correct. Static electricity builds up during liquid transfer. Bonding (cable between tank and receiving container) plus grounding equalizes potential to prevent ignition.

Question 16 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

Question 17 of 20

When emergency-braking a smooth-bore tanker:

Brake hard
Anticipate forward surge that can throw your weight against the wheel and may push the rig past your intended stopping distance
Use only trailer brake
No special concern

Correct. Forward surge can dramatically push a smooth-bore tank rig further than expected. Plan stopping distance with significant additional margin.

Question 18 of 20

The driver should plan extra time for:

Acceleration, braking, and turning a fully loaded tanker
Lunch
Sleep only
Refueling only

Correct. A loaded tanker accelerates slower, brakes longer, and turns wider. Plan your trip and reactions accordingly.

Question 19 of 20

Compartmented tanks have:

Liquid-tight bulkheads dividing the tank into separate sections
No divisions
Smooth interior
Only baffles

Correct. Compartmented tanks have liquid-tight bulkheads. Each compartment is loaded separately, allowing different products in one trailer.

Question 20 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

About the Pennsylvania Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Pennsylvania Department of Transportation Driver Licensing follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Pennsylvania CDL practice tests.