Pennsylvania Air Brakes CDL Practice Test

This is a free 20-question practice test for the Air Brakes portion of the Pennsylvania Commercial Driver's License knowledge exam. Questions are pulled from a pool of 71 drawn from the AAMVA CDL Manual, which is the source document the Pennsylvania Department of Transportation Driver Licensing uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Pennsylvania.

Question 1 of 20

When should you use the trailer hand valve to slow the rig?

Whenever you want trailer-only braking
Never; using the trailer hand valve alone can cause a trailer skid
Always when going downhill
Only on dry pavement

Correct. Using the trailer hand valve alone applies brakes only at the trailer wheels and can cause the trailer to lock up and skid. Always use the foot valve to brake.

Question 2 of 20

When brake drums or shoes get very hot, you should:

Park immediately
Continue driving
Pull over and let them cool, but do not apply the parking brake until they have cooled
Throw water on them

Correct. Park where you can let the brakes cool. Do not apply the parking (spring) brake on overheated brakes — it can damage them or cause warpage.

Question 3 of 20

Manual slack adjusters must be adjusted:

Only by a mechanic at the dealership
By the driver, when needed, following manufacturer specifications
Never
Only at the time of vehicle inspection

Correct. Drivers may adjust manual slack adjusters in compliance with manufacturer specifications. Automatic slack adjusters are now standard but still require periodic checking.

Question 4 of 20

A long downgrade requires:

Riding the brakes the whole way
Selecting a low gear before starting down and using intermittent firm brake applications
Coasting in neutral
Using the engine brake only

Correct. Pick a low gear before starting down. Use the brakes in firm, intermittent applications: brake to 5 mph below safe speed, release, repeat.

Question 5 of 20

Continuous use of the brakes on a long downgrade can cause:

Improved braking
Brake fade — loss of braking effectiveness due to overheating
No effect
Faster wear of the air compressor

Correct. Holding the brakes overheats them and causes brake fade — drums expand and brake compounds lose effectiveness, reducing braking force.

Question 6 of 20

Brake fade is the result of:

Cold brakes
Worn linings only
Heat from continuous use, which reduces braking effectiveness
Air leaks

Correct. Brake fade comes from heat. Manage downgrade speed by gear selection plus intermittent firm brake use, not continuous light pressure.

Question 7 of 20

You should perform a static air-leakage test by:

Driving and watching the gauge
With the engine off, brakes released, watching air pressure for one minute
With the engine running at high RPM
By tapping the air tank with a wrench

Correct. Engine off, brakes released, fully charged system: watch for air loss over one minute. Then apply brakes and check again.

Question 8 of 20

When releasing brakes after a hard stop, you should:

Continue holding the brakes
Release smoothly to allow air to refill the tanks
Pump the brakes
Apply the parking brake immediately

Correct. Release the brakes smoothly. Air tanks refill while you drive; allow the compressor to recharge the system before the next braking event.

Question 9 of 20

When should you NOT use the parking brakes?

When the vehicle is parked
When the brakes are very hot, such as after a long downgrade — they could damage if applied
At any time
When the engine is off

Correct. Hot brakes can be damaged by the spring brakes contracting against hot drums. Let the brakes cool before parking.

Question 10 of 20

Modern dual-circuit air-brake systems are required so that:

Two drivers can operate the truck
If one part of the system fails, the other still provides braking
The truck looks newer
Air pressure builds faster

Correct. Dual systems separate primary and secondary brake circuits so that a failure in one (rear or trailer) still leaves brakes available on the other axle group.

Question 11 of 20

You are driving a fully loaded combination vehicle on a steep downgrade. Your safe speed is 30 mph and you have already shifted to a lower gear. The proper braking technique is to:

Hold the brakes lightly the whole way
Apply firmly to slow to 25 mph (5 mph below safe speed), release, and let speed build back to 30, then repeat
Stay at 30 mph
Apply only the trailer brake

Correct. The "snub-and-release" method: brake firmly to drop 5 mph below safe speed, release until safe speed returns, repeat. Holding the brakes overheats them.

Question 12 of 20

In a dual air-brake system, the time required for air pressure to build from 85 to 100 psi should be no more than:

15 seconds
30 seconds
45 seconds
120 seconds

Correct. In dual air-brake systems, air should build from 85 to 100 psi within 45 seconds at engine governed RPM.

Question 13 of 20

For a single vehicle with engine off and brakes applied, the maximum allowable air-loss rate is:

1 psi/min
2 psi/min
3 psi/min
4 psi/min

Correct. A single vehicle is allowed no more than 3 psi/min with brakes fully applied.

Question 14 of 20

The trailer air-supply control:

Is a yellow diamond knob
Is a red eight-sided (octagonal) knob
Is a green knob
Is the same knob as the parking brake

Correct. The trailer air-supply (tractor protection) is a red eight-sided knob. Push in to supply air to the trailer; pull out to shut off air.

Question 15 of 20

Antilock braking systems (ABS):

Replace the regular brakes
Help prevent wheel lockup so you can keep steering during emergency braking
Reduce braking distance under normal conditions
Are not required on combination vehicles

Correct. ABS prevents wheel lockup during hard braking, allowing you to steer to safety. ABS does not necessarily shorten stopping distance.

Question 16 of 20

Wet brakes:

Improve braking
Cause reduced power, brake pulling, or wheel lockup
Have no effect
Are normal in winter

Correct. After fording water, brakes may be wet. Drive slowly while applying light brake pressure to dry them.

Question 17 of 20

You hear a steady "ssss" sound while parked with the engine off. This is most likely:

Normal venting
An air leak that needs immediate attention
The compressor running
Trailer brakes releasing

Correct. A steady hiss with the engine off indicates an air leak — find and repair before driving.

Question 18 of 20

The parking-brake control:

Is a yellow diamond-shaped knob
Is a red round knob
Is a green knob
Does not exist on modern trucks

Correct. The parking-brake control is a yellow diamond-shaped knob, distinct from the red round trailer-supply knob.

Question 19 of 20

If a trailer breaks away, the emergency brakes on the trailer will be applied because:

The driver pulled the parking brake
The air supply to the trailer is interrupted, releasing the spring brakes on the trailer
The trailer wiring shuts down
The trailer ABS engages

Correct. When the air line breaks (or is disconnected), trailer air pressure drops and the trailer spring brakes apply, stopping the trailer.

Question 20 of 20

If you must drive a vehicle with manual front-wheel-brake limiting valve, you should keep it in the "normal" position:

Always
Only on slick roads
In the slippery position only
Only when empty

Correct. Keep the front-wheel limiting valve in the "normal" position. Modern trucks rarely have this valve, but if equipped, leaving it in "slippery" reduces front braking and lengthens stopping distance.

About the Pennsylvania Air Brakes exam

States typically administer 25 Air Brakes questions and require 80% to pass. Questions cover air-brake system parts, dual systems, supply pressure, brake-system warning, slack adjusters, the parking brake, the spring brake, the pre-trip air-system check, and the proper way to perform a leakage-rate test.

The Pennsylvania Department of Transportation Driver Licensing follows the federal CDL standards established by FMCSA. To earn the Air Brakes credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Air Brakes question bank or browse all Pennsylvania CDL practice tests.