Ohio Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Ohio Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Ohio Bureau of Motor Vehicles uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Ohio.

Question 1 of 20

A tanker hauling food-grade product (e.g., milk):

Often uses a smooth-bore tank for cleaning
Uses a baffled tank
Uses a compartmented tank only
Uses no tank

Correct. Smooth-bore tanks (no internal baffles) are easier to clean for food-grade products. The trade-off is severe surge — drive slower and brake earlier.

Question 2 of 20

Tankers have a high center of gravity because:

The driver sits high
The load is in a tall, narrow tank
The cargo is light
The cab is wide

Correct. A tank carries its load high above the road. The center of gravity is much higher than for a flatbed of the same weight, increasing rollover risk.

Question 3 of 20

Bonding and grounding during product transfer:

Equalizes electrical potential between the tank and receiving container, preventing static-spark ignition
Charges the battery
Cools the load
Speeds delivery

Correct. Static electricity builds up during liquid transfer. Bonding (cable between tank and receiving container) plus grounding equalizes potential to prevent ignition.

Question 4 of 20

A "bottom-loaded" tank:

Is loaded through bottom valves to reduce vapor and static
Is loaded only at the top
Carries cargo at the bottom only
Has no top vents

Correct. Bottom-loading uses sealed bottom-loading equipment with vapor recovery, reducing static and vapor escape compared to splash-loading from the top.

Question 5 of 20

When unloading product from a cargo tank, you should:

Verify the receiving container can hold the load, bond and ground, control the flow rate, and remain within 25 feet for flammables
Walk away
Maximize flow rate
Smoke nearby

Correct. Pre-check receiving container, bond and ground, control flow rate to prevent splash and spill, and remain attentive for flammable liquids.

Question 6 of 20

A tanker with an empty compartment between two full compartments may:

Slosh forward and backward, hard to predict
Be smoother
Drive itself
Have no surge

Correct. Mixed full and empty compartments produce complex surge patterns. Plan acceleration and braking conservatively.

Question 7 of 20

Tank specification "MC-306" or "DOT-406" generally refers to:

Cargo tanks designed for non-pressure flammable and combustible liquids (e.g., gasoline, diesel)
High-pressure gases
Cryogenic liquids
Hazardous solids

Correct. MC-306 (older) and DOT-406 (current) are non-pressure cargo tanks for flammable and combustible liquids — typical fuel tankers.

Question 8 of 20

Loading dock procedure for cargo tanks of flammable liquid:

Set parking brake, chock wheels, shut off engine, ground and bond, monitor loading, follow loading-rack procedures
Leave the engine running
Skip the chocks
Smoke nearby

Correct. Standard loading-rack procedure: brake set, chocks in, engine off, bond and ground, monitor loading, follow rack-specific procedures (vapor recovery, load arms, etc.).

Question 9 of 20

Vapor recovery during loading:

Is used at terminals to capture flammable vapors
Replaces the cargo
Is forbidden
Is used only at night

Correct. Vapor recovery captures flammable vapors displaced as product is loaded, returning them to storage. Required at most modern fuel terminals.

Question 10 of 20

Tanker pre-trip should specifically check:

Tank shell, intake/discharge/cut-off valves, manhole covers, venting devices, and pressure-relief equipment
Only the tires
Only the engine
Only the placards

Correct. In addition to standard pre-trip, inspect the tank shell, all valves, manhole covers, vents, and pressure-relief devices.

Question 11 of 20

Side-to-side surge is most likely to cause:

Improved fuel economy
Rollover, especially on curves and in evasive maneuvers
No effect
Better braking

Correct. Side-to-side surge can amplify side-loading forces, contributing to rollover on curves and exit ramps.

Question 12 of 20

Outage requirements:

Vary by liquid because of differing thermal expansion rates
Are always 1 percent
Do not exist
Are only for water

Correct. Outage requirements differ by product. Gasoline expands more than diesel, ethanol expands differently, etc. Check the shipping paper or product specifications.

Question 13 of 20

Outage refers to:

Empty space left at the top of a tank to allow liquid expansion
The brake-out system
A power failure
A driver shortage

Correct. Outage is the empty space left at the top of a tank to allow liquid to expand as it warms. Different liquids require different outage percentages.

Question 14 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 15 of 20

A heavy liquid load with a baffled tank may still surge:

Front-to-back, despite the baffles
Not at all
Less than smooth-bore but baffles do not stop side-to-side surge
None of the above

Correct. Baffles reduce front-to-back surge but do not affect side-to-side surge — bulkheads are typically transverse, not longitudinal.

Question 16 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 17 of 20

A "tank vehicle" requiring an N endorsement is generally defined as:

Any commercial vehicle
A vehicle used to transport liquid or gaseous materials in a tank with rated capacity of 1,000 gallons or more, individual tanks of 119+ gallons
Only fuel trucks
Only vehicles over 80,000 lbs

Correct. The N endorsement is required for any commercial vehicle hauling liquid or gas in a permanently mounted tank or portable tank with rated capacity of 1,000+ gallons (and individual tanks of 119+ gallons).

Question 18 of 20

A "baffled" tank has:

Walls with holes that slow surge but allow flow
No walls
Only one compartment
Outside reinforcement

Correct. Baffled tanks have internal bulkheads with holes — they slow surge but still allow product to flow through during loading and unloading.

Question 19 of 20

When braking a partially filled smooth-bore tank, you should:

Brake hard at the last minute
Brake gently and start braking earlier than usual to compensate for surge
Use only the trailer hand valve
Pump the brakes

Correct. In smooth-bore tanks, surge is severe. Brake gently and earlier than you would in a dry-van trailer to avoid being pushed forward.

Question 20 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

About the Ohio Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Ohio Bureau of Motor Vehicles follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Ohio CDL practice tests.