New York Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the New York Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the New York State Department of Motor Vehicles uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in New York.

Question 1 of 20

You should never load a tank completely full because:

It is illegal in all states
Liquids expand when warmed and need outage; over-filling can rupture the tank
Trucks won't move
It saves no time

Correct. Liquids expand with temperature. Without outage, a warming load can over-pressurize and rupture the tank.

Question 2 of 20

When you discover a leak in a cargo tank carrying flammable liquid:

Continue to the destination
Stop in a safe location, secure the area, contact emergency response and the carrier — never transfer cargo on the road
Try to drive around the leak
Pour water on it

Correct. A leaking flammable cargo tank is a major incident — secure the area, evacuate per the ERG, contact emergency services. Never attempt roadside cargo transfer.

Question 3 of 20

Pressure relief devices on cargo tanks are designed to:

Open if pressure inside exceeds safe limits, releasing product or vapor before the tank ruptures
Increase pressure
Be tightened down
Stay closed at all times

Correct. Pressure relief valves open at a set pressure to prevent tank rupture. Tampering with them is illegal and dangerous.

Question 4 of 20

Cargo tanks must be inspected and tested:

Periodically per CFR requirements; intervals depend on tank specification (MC-306, MC-307, MC-312, DOT-406, etc.)
Once a decade
Never
Only when leaks appear

Correct. Cargo tanks have specific inspection and test schedules based on their DOT specification (visual, leakage, internal, pressure, and thickness tests).

Question 5 of 20

When backing a tanker, you should:

Move slowly and watch for the high mounted lights and clearance, since the tank shape may affect visibility
Move quickly
Use only the trailer brake
Skip the helper

Correct. Tankers can have unusual mirror angles and rear visibility. Use a helper, move slowly, and watch for tank-mount lights and overhead clearance.

Question 6 of 20

A tank with multiple compartments may have:

Different products in each compartment, requiring careful unloading sequence and verification
Only one product
No internal walls
No discharge

Correct. Compartmented tanks (common on fuel-delivery trucks) carry different grades or different products. Verify the destination tank before opening any discharge valve.

Question 7 of 20

Tankers have a high center of gravity because:

The driver sits high
The load is in a tall, narrow tank
The cargo is light
The cab is wide

Correct. A tank carries its load high above the road. The center of gravity is much higher than for a flatbed of the same weight, increasing rollover risk.

Question 8 of 20

Tank vehicles should not be driven:

On long downgrades without a lower gear and intermittent firm braking
On any highway
Anywhere
At night

Correct. On long downgrades, select a low gear before starting down and use firm intermittent brake applications to prevent fade.

Question 9 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 10 of 20

Carrying a smooth-bore tank up a ramp or off a curb:

Causes minimal surge
Can produce strong front-to-back surge that affects throttle and traction
Has no effect
Improves traction

Correct. Climbing causes the load to surge backward and then forward as you level off — affecting throttle response, traction, and braking.

Question 11 of 20

A loaded tanker on a curve is most likely to:

Roll over because surge plus high CG amplifies side forces
Skid in a straight line
Brake faster
Steer easier

Correct. Side surge plus high CG creates a tipping moment well above what a flat-bed of equal weight produces. Speed reduction in advance is the only safe answer.

Question 12 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

Question 13 of 20

Outage requirements:

Vary by liquid because of differing thermal expansion rates
Are always 1 percent
Do not exist
Are only for water

Correct. Outage requirements differ by product. Gasoline expands more than diesel, ethanol expands differently, etc. Check the shipping paper or product specifications.

Question 14 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

Question 15 of 20

When emergency-braking a smooth-bore tanker:

Brake hard
Anticipate forward surge that can throw your weight against the wheel and may push the rig past your intended stopping distance
Use only trailer brake
No special concern

Correct. Forward surge can dramatically push a smooth-bore tank rig further than expected. Plan stopping distance with significant additional margin.

Question 16 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 17 of 20

Tank specification "MC-306" or "DOT-406" generally refers to:

Cargo tanks designed for non-pressure flammable and combustible liquids (e.g., gasoline, diesel)
High-pressure gases
Cryogenic liquids
Hazardous solids

Correct. MC-306 (older) and DOT-406 (current) are non-pressure cargo tanks for flammable and combustible liquids — typical fuel tankers.

Question 18 of 20

When you stop a placarded tanker carrying flammable liquid at a railroad crossing, you must stop:

On the rails
Between 15 and 50 feet from the nearest rail, then proceed only when safe
Anywhere
Only if a train is in sight

Correct. Placarded hazmat (which most fuel tankers are) must stop 15 to 50 feet from the nearest rail. Look, listen, and cross only when clear.

Question 19 of 20

Tank specification "MC-307" or "DOT-407" generally refers to:

Cargo tanks for low-pressure liquids and certain hazardous chemicals
Explosives
Bulk solids
Refrigerated gases

Correct. MC-307/DOT-407 are insulated low-pressure tanks for chemicals — common for many industrial liquids.

Question 20 of 20

When driving a tanker through a sharp bend at the recommended speed for cars:

You are likely to roll over
You are safe
You will accelerate
Brakes engage automatically

Correct. Tanker rollovers regularly happen at posted "car" curve speeds. Slow well below posted speeds in a loaded tanker.

About the New York Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The New York State Department of Motor Vehicles follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all New York CDL practice tests.