Missouri Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Missouri Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Missouri Department of Revenue Driver License Bureau uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Missouri.

Question 1 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

Question 2 of 20

You should never load a tank completely full because:

It is illegal in all states
Liquids expand when warmed and need outage; over-filling can rupture the tank
Trucks won't move
It saves no time

Correct. Liquids expand with temperature. Without outage, a warming load can over-pressurize and rupture the tank.

Question 3 of 20

A pressure-relief device that vents during transit:

Is a normal occurrence
Is a serious malfunction or over-fill — stop and investigate
Means the tank is empty
Means the load is cold

Correct. Continuous venting indicates over-pressure (often from over-fill or sun heating an over-filled tank). Stop and investigate; do not continue with a venting tank.

Question 4 of 20

A tanker with a high center of gravity is most prone to rollover during:

Straight-line driving
Tight curves, evasive maneuvers, and exit ramps
Backing
Stopping

Correct. High center of gravity makes tankers roll on tight curves, sudden lane changes, and exit ramps. Slow well in advance.

Question 5 of 20

When you drive a tanker on slippery roads, you should:

Drive faster
Reduce speed substantially and increase following distance
Use only the trailer brake
Maintain normal speed

Correct. Reduce speed by at least one-third on wet roads, by half on snow. Liquid loads make recovery from a skid much harder.

Question 6 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 7 of 20

Outage refers to:

Empty space left at the top of a tank to allow liquid expansion
The brake-out system
A power failure
A driver shortage

Correct. Outage is the empty space left at the top of a tank to allow liquid to expand as it warms. Different liquids require different outage percentages.

Question 8 of 20

Cargo tanks must be inspected and tested:

Periodically per CFR requirements; intervals depend on tank specification (MC-306, MC-307, MC-312, DOT-406, etc.)
Once a decade
Never
Only when leaks appear

Correct. Cargo tanks have specific inspection and test schedules based on their DOT specification (visual, leakage, internal, pressure, and thickness tests).

Question 9 of 20

The driver should plan extra time for:

Acceleration, braking, and turning a fully loaded tanker
Lunch
Sleep only
Refueling only

Correct. A loaded tanker accelerates slower, brakes longer, and turns wider. Plan your trip and reactions accordingly.

Question 10 of 20

A "tank vehicle" requiring an N endorsement is generally defined as:

Any commercial vehicle
A vehicle used to transport liquid or gaseous materials in a tank with rated capacity of 1,000 gallons or more, individual tanks of 119+ gallons
Only fuel trucks
Only vehicles over 80,000 lbs

Correct. The N endorsement is required for any commercial vehicle hauling liquid or gas in a permanently mounted tank or portable tank with rated capacity of 1,000+ gallons (and individual tanks of 119+ gallons).

Question 11 of 20

When braking a partially filled smooth-bore tank, you should:

Brake hard at the last minute
Brake gently and start braking earlier than usual to compensate for surge
Use only the trailer hand valve
Pump the brakes

Correct. In smooth-bore tanks, surge is severe. Brake gently and earlier than you would in a dry-van trailer to avoid being pushed forward.

Question 12 of 20

On a wet road, a tanker should:

Maintain normal speed
Reduce speed by about one-third
Drive faster
Use only the trailer brake

Correct. On wet pavement, reduce speed by about one-third. On snow, by about one-half. Tankers are less forgiving than dry vans on slippery roads.

Question 13 of 20

When driving with a load that has a low specific gravity (e.g., gasoline) versus high (e.g., asphalt), you should:

Drive the same
Adjust for the differences in surge dynamics, weight distribution, and braking
Skip braking
Run hot

Correct. Different products have different densities, surge characteristics, and weight distributions. Adjust speed and braking for the load.

Question 14 of 20

Side-to-side surge is most likely to cause:

Improved fuel economy
Rollover, especially on curves and in evasive maneuvers
No effect
Better braking

Correct. Side-to-side surge can amplify side-loading forces, contributing to rollover on curves and exit ramps.

Question 15 of 20

Tanker pre-trip should specifically check:

Tank shell, intake/discharge/cut-off valves, manhole covers, venting devices, and pressure-relief equipment
Only the tires
Only the engine
Only the placards

Correct. In addition to standard pre-trip, inspect the tank shell, all valves, manhole covers, vents, and pressure-relief devices.

Question 16 of 20

When unloading from a top-mounted hatch, you should:

Use the ladder safely, follow fall-protection rules, secure the hatch after
Skip the ladder
Jump down
Open all hatches at once

Correct. Top-mount work involves fall hazard. Use the ladder safely, follow fall-protection procedures, and secure hatches after.

Question 17 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

Question 18 of 20

A tanker with an empty compartment between two full compartments may:

Slosh forward and backward, hard to predict
Be smoother
Drive itself
Have no surge

Correct. Mixed full and empty compartments produce complex surge patterns. Plan acceleration and braking conservatively.

Question 19 of 20

Bonding and grounding during product transfer:

Equalizes electrical potential between the tank and receiving container, preventing static-spark ignition
Charges the battery
Cools the load
Speeds delivery

Correct. Static electricity builds up during liquid transfer. Bonding (cable between tank and receiving container) plus grounding equalizes potential to prevent ignition.

Question 20 of 20

Vapor recovery during loading:

Is used at terminals to capture flammable vapors
Replaces the cargo
Is forbidden
Is used only at night

Correct. Vapor recovery captures flammable vapors displaced as product is loaded, returning them to storage. Required at most modern fuel terminals.

About the Missouri Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Missouri Department of Revenue Driver License Bureau follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Missouri CDL practice tests.