Kentucky Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Kentucky Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Kentucky Department of Vehicle Regulation uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Kentucky.

Question 1 of 20

You should never load a tank completely full because:

It is illegal in all states
Liquids expand when warmed and need outage; over-filling can rupture the tank
Trucks won't move
It saves no time

Correct. Liquids expand with temperature. Without outage, a warming load can over-pressurize and rupture the tank.

Question 2 of 20

A tank with multiple compartments may have:

Different products in each compartment, requiring careful unloading sequence and verification
Only one product
No internal walls
No discharge

Correct. Compartmented tanks (common on fuel-delivery trucks) carry different grades or different products. Verify the destination tank before opening any discharge valve.

Question 3 of 20

A loaded tanker traveling 10 mph above the safe curve speed has a:

Lower rollover risk
Significantly higher rollover risk because rollover threshold scales with speed squared
Same risk
Better handling

Correct. Centripetal force scales with speed squared. Just 10 mph over safe speed can take you past the rollover threshold of a loaded tanker.

Question 4 of 20

A "baffled" tank has:

Walls with holes that slow surge but allow flow
No walls
Only one compartment
Outside reinforcement

Correct. Baffled tanks have internal bulkheads with holes — they slow surge but still allow product to flow through during loading and unloading.

Question 5 of 20

Outage requirements:

Vary by liquid because of differing thermal expansion rates
Are always 1 percent
Do not exist
Are only for water

Correct. Outage requirements differ by product. Gasoline expands more than diesel, ethanol expands differently, etc. Check the shipping paper or product specifications.

Question 6 of 20

A "bottom-loaded" tank:

Is loaded through bottom valves to reduce vapor and static
Is loaded only at the top
Carries cargo at the bottom only
Has no top vents

Correct. Bottom-loading uses sealed bottom-loading equipment with vapor recovery, reducing static and vapor escape compared to splash-loading from the top.

Question 7 of 20

Loading dock procedure for cargo tanks of flammable liquid:

Set parking brake, chock wheels, shut off engine, ground and bond, monitor loading, follow loading-rack procedures
Leave the engine running
Skip the chocks
Smoke nearby

Correct. Standard loading-rack procedure: brake set, chocks in, engine off, bond and ground, monitor loading, follow rack-specific procedures (vapor recovery, load arms, etc.).

Question 8 of 20

Side-to-side surge is most likely to cause:

Improved fuel economy
Rollover, especially on curves and in evasive maneuvers
No effect
Better braking

Correct. Side-to-side surge can amplify side-loading forces, contributing to rollover on curves and exit ramps.

Question 9 of 20

Cargo tanks must be inspected and tested:

Periodically per CFR requirements; intervals depend on tank specification (MC-306, MC-307, MC-312, DOT-406, etc.)
Once a decade
Never
Only when leaks appear

Correct. Cargo tanks have specific inspection and test schedules based on their DOT specification (visual, leakage, internal, pressure, and thickness tests).

Question 10 of 20

A "tank vehicle" requiring an N endorsement is generally defined as:

Any commercial vehicle
A vehicle used to transport liquid or gaseous materials in a tank with rated capacity of 1,000 gallons or more, individual tanks of 119+ gallons
Only fuel trucks
Only vehicles over 80,000 lbs

Correct. The N endorsement is required for any commercial vehicle hauling liquid or gas in a permanently mounted tank or portable tank with rated capacity of 1,000+ gallons (and individual tanks of 119+ gallons).

Question 11 of 20

Carrying a smooth-bore tank up a ramp or off a curb:

Causes minimal surge
Can produce strong front-to-back surge that affects throttle and traction
Has no effect
Improves traction

Correct. Climbing causes the load to surge backward and then forward as you level off — affecting throttle response, traction, and braking.

Question 12 of 20

When you stop a placarded tanker carrying flammable liquid at a railroad crossing, you must stop:

On the rails
Between 15 and 50 feet from the nearest rail, then proceed only when safe
Anywhere
Only if a train is in sight

Correct. Placarded hazmat (which most fuel tankers are) must stop 15 to 50 feet from the nearest rail. Look, listen, and cross only when clear.

Question 13 of 20

Tank specification "MC-307" or "DOT-407" generally refers to:

Cargo tanks for low-pressure liquids and certain hazardous chemicals
Explosives
Bulk solids
Refrigerated gases

Correct. MC-307/DOT-407 are insulated low-pressure tanks for chemicals — common for many industrial liquids.

Question 14 of 20

Tankers have a high center of gravity because:

The driver sits high
The load is in a tall, narrow tank
The cargo is light
The cab is wide

Correct. A tank carries its load high above the road. The center of gravity is much higher than for a flatbed of the same weight, increasing rollover risk.

Question 15 of 20

When the surge in a tanker pushes the rig forward at a stop, you may:

Brake harder
Be pushed past the intended stopping point
Skid backward
Have no effect

Correct. Forward surge can push the entire rig forward — past stop lines, into intersections, into the vehicle ahead. Plan your stops with extra distance.

Question 16 of 20

The driver should plan extra time for:

Acceleration, braking, and turning a fully loaded tanker
Lunch
Sleep only
Refueling only

Correct. A loaded tanker accelerates slower, brakes longer, and turns wider. Plan your trip and reactions accordingly.

Question 17 of 20

A "smooth bore" tank has:

No internal divisions
Internal baffles
Compartments
Reinforcement rings

Correct. A smooth-bore tank has no internal divisions or baffles. Surge is dramatic; brake gently to avoid being pushed forward by the load.

Question 18 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 19 of 20

A double trailer tanker requires:

Both N (Tanker) and T (Doubles/Triples) endorsements, plus possibly H (Hazmat)
Only the N endorsement
No endorsements
Only the H endorsement

Correct. Pulling more than one tank requires Doubles/Triples (T) plus Tanker (N) endorsements. Add Hazmat (H) — together written X — for hazardous liquid loads.

Question 20 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

About the Kentucky Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Kentucky Department of Vehicle Regulation follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Kentucky CDL practice tests.