Iowa Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Iowa Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Iowa Department of Transportation Motor Vehicle Division uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Iowa.

Question 1 of 20

When unloading product from a cargo tank, you should:

Verify the receiving container can hold the load, bond and ground, control the flow rate, and remain within 25 feet for flammables
Walk away
Maximize flow rate
Smoke nearby

Correct. Pre-check receiving container, bond and ground, control flow rate to prevent splash and spill, and remain attentive for flammable liquids.

Question 2 of 20

When you stop a placarded tanker carrying flammable liquid at a railroad crossing, you must stop:

On the rails
Between 15 and 50 feet from the nearest rail, then proceed only when safe
Anywhere
Only if a train is in sight

Correct. Placarded hazmat (which most fuel tankers are) must stop 15 to 50 feet from the nearest rail. Look, listen, and cross only when clear.

Question 3 of 20

Tank vehicles should not be driven:

On long downgrades without a lower gear and intermittent firm braking
On any highway
Anywhere
At night

Correct. On long downgrades, select a low gear before starting down and use firm intermittent brake applications to prevent fade.

Question 4 of 20

When driving a tanker through a sharp bend at the recommended speed for cars:

You are likely to roll over
You are safe
You will accelerate
Brakes engage automatically

Correct. Tanker rollovers regularly happen at posted "car" curve speeds. Slow well below posted speeds in a loaded tanker.

Question 5 of 20

A "baffled" tank has:

Walls with holes that slow surge but allow flow
No walls
Only one compartment
Outside reinforcement

Correct. Baffled tanks have internal bulkheads with holes — they slow surge but still allow product to flow through during loading and unloading.

Question 6 of 20

When driving with a load that has a low specific gravity (e.g., gasoline) versus high (e.g., asphalt), you should:

Drive the same
Adjust for the differences in surge dynamics, weight distribution, and braking
Skip braking
Run hot

Correct. Different products have different densities, surge characteristics, and weight distributions. Adjust speed and braking for the load.

Question 7 of 20

Compartmented tanks have:

Liquid-tight bulkheads dividing the tank into separate sections
No divisions
Smooth interior
Only baffles

Correct. Compartmented tanks have liquid-tight bulkheads. Each compartment is loaded separately, allowing different products in one trailer.

Question 8 of 20

Tankers have a high center of gravity because:

The driver sits high
The load is in a tall, narrow tank
The cargo is light
The cab is wide

Correct. A tank carries its load high above the road. The center of gravity is much higher than for a flatbed of the same weight, increasing rollover risk.

Question 9 of 20

Outage refers to:

Empty space left at the top of a tank to allow liquid expansion
The brake-out system
A power failure
A driver shortage

Correct. Outage is the empty space left at the top of a tank to allow liquid to expand as it warms. Different liquids require different outage percentages.

Question 10 of 20

When driving a tanker, you should:

Drive faster on curves
Drive slower than posted curve speeds, especially on exit ramps
Use only the trailer brake
Match car speeds

Correct. Posted advisory speeds assume cars. A loaded tanker may roll over at the posted speed — slow well below posted speeds for ramps and curves.

Question 11 of 20

Bonding and grounding during product transfer:

Equalizes electrical potential between the tank and receiving container, preventing static-spark ignition
Charges the battery
Cools the load
Speeds delivery

Correct. Static electricity builds up during liquid transfer. Bonding (cable between tank and receiving container) plus grounding equalizes potential to prevent ignition.

Question 12 of 20

When you drive a tanker on slippery roads, you should:

Drive faster
Reduce speed substantially and increase following distance
Use only the trailer brake
Maintain normal speed

Correct. Reduce speed by at least one-third on wet roads, by half on snow. Liquid loads make recovery from a skid much harder.

Question 13 of 20

On a wet road, a tanker should:

Maintain normal speed
Reduce speed by about one-third
Drive faster
Use only the trailer brake

Correct. On wet pavement, reduce speed by about one-third. On snow, by about one-half. Tankers are less forgiving than dry vans on slippery roads.

Question 14 of 20

Cargo tanks must be inspected and tested:

Periodically per CFR requirements; intervals depend on tank specification (MC-306, MC-307, MC-312, DOT-406, etc.)
Once a decade
Never
Only when leaks appear

Correct. Cargo tanks have specific inspection and test schedules based on their DOT specification (visual, leakage, internal, pressure, and thickness tests).

Question 15 of 20

A heavy liquid load with a baffled tank may still surge:

Front-to-back, despite the baffles
Not at all
Less than smooth-bore but baffles do not stop side-to-side surge
None of the above

Correct. Baffles reduce front-to-back surge but do not affect side-to-side surge — bulkheads are typically transverse, not longitudinal.

Question 16 of 20

A tank with multiple compartments may have:

Different products in each compartment, requiring careful unloading sequence and verification
Only one product
No internal walls
No discharge

Correct. Compartmented tanks (common on fuel-delivery trucks) carry different grades or different products. Verify the destination tank before opening any discharge valve.

Question 17 of 20

You should never load a tank completely full because:

It is illegal in all states
Liquids expand when warmed and need outage; over-filling can rupture the tank
Trucks won't move
It saves no time

Correct. Liquids expand with temperature. Without outage, a warming load can over-pressurize and rupture the tank.

Question 18 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 19 of 20

Front-to-back surge is most likely to cause:

The vehicle to be pushed forward when braking
The vehicle to roll over
Better braking
No effect

Correct. Front-to-back surge pushes the rig forward when you brake — drivers have been pushed through stop lines by an unexpected forward surge.

Question 20 of 20

A tanker with a high center of gravity is most prone to rollover during:

Straight-line driving
Tight curves, evasive maneuvers, and exit ramps
Backing
Stopping

Correct. High center of gravity makes tankers roll on tight curves, sudden lane changes, and exit ramps. Slow well in advance.

About the Iowa Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Iowa Department of Transportation Motor Vehicle Division follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Iowa CDL practice tests.