Hawaii Hazmat CDL Practice Test

This is a free 20-question practice test for the Hazmat portion of the Hawaii Commercial Driver's License knowledge exam. Questions are pulled from a pool of 68 drawn from the AAMVA CDL Manual, which is the source document the Hawaii Driver License Office uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Hawaii.

Question 1 of 20

Hazard Class 1 is:

Flammable liquids
Explosives
Corrosives
Radioactive materials

Correct. Class 1 covers explosives, divided into divisions 1.1 through 1.6 by mass-explosion and projection hazard.

Question 2 of 20

The Hazmat (H) endorsement requires:

Only a knowledge test
A knowledge test plus a TSA Threat Assessment background check
Just a fee
A skills test only

Correct. Hazmat applicants pass a knowledge test and complete the TSA Threat Assessment (HME), which involves fingerprints and an FBI background check.

Question 3 of 20

When loading hazmat that requires segregation, the driver must:

Refuse to mix incompatible materials in the same vehicle, per the segregation table
Mix them anyway
Load whatever fits
Stack on top

Correct. The segregation table in 49 CFR §177.848 lists which classes cannot be loaded together. Refusing improperly mixed loads is the driver's responsibility.

Question 4 of 20

When a hazmat shipment crosses international borders:

Documentation may need to comply with both US and Canadian/Mexican regulations
No special documentation is needed
Only US regulations apply
Only foreign regulations apply

Correct. Cross-border hazmat may require documentation in compliance with both jurisdictions, plus customs paperwork.

Question 5 of 20

The Emergency Response Guidebook (ERG) is used to:

Plan routes
Look up the four-digit hazmat ID number to find emergency response procedures
Calculate fuel cost
Find truck stops

Correct. The ERG cross-references the four-digit ID number from the placard or shipping paper to a guide page with isolation distance, response procedures, and first aid.

Question 6 of 20

Mixing certain hazmat in one shipment is prohibited because:

Of cost
They may react dangerously together; the segregation table specifies prohibitions
It is too heavy
Of regulations on cargo color

Correct. Some classes react dangerously when mixed (e.g., acids with cyanides, oxidizers with flammables). The segregation table prohibits these mixtures.

Question 7 of 20

A hazmat carrier with hazmat cargo must conduct security awareness training:

Once at hire
Once every 3 years for each driver
Annually
Never

Correct. PHMSA requires re-training every three years, including security awareness and the carrier's in-depth security plan if applicable.

Question 8 of 20

Subsidiary risk labels on a package indicate:

Additional hazards beyond the primary hazard
Just decoration
The price
The weight

Correct. Some materials have multiple hazards. The primary hazard is shown on the top-class label; subsidiary risks (e.g., toxic AND flammable) are shown on additional labels.

Question 9 of 20

When you stop a hazmat-placarded vehicle at the side of the road, you must place reflective triangles:

Within 10 minutes of stopping
Immediately, but never use flares with Division 1.1, 1.2, 1.3 explosives, oxidizers, or flammable cargo
Only if dark
Only if other vehicles are present

Correct. Place warning devices within 10 minutes. Never use flares with explosives, flammable cargo, or oxidizers — use reflective triangles or red lanterns.

Question 10 of 20

A hazmat driver must complete which special training?

General awareness, function-specific, safety, security awareness, and in-depth security if a security plan is required
Forklift training
Basic first aid only
Defensive driving only

Correct. PHMSA requires general awareness, function-specific, safety, security awareness, and in-depth security training (when a security plan applies). Carriers document and re-train every three years.

Question 11 of 20

When parking a placarded hazmat vehicle at a truck stop overnight, you should:

Park in a designated hazmat parking area, follow attendance rules for explosives, never block traffic
Park behind the fuel pumps
Park in the entrance
Park anywhere

Correct. Use designated hazmat parking. Explosives and certain other materials require attended parking; review the carrier's policy and federal rules.

Question 12 of 20

When loading or unloading cargo tanks of flammable liquid, the driver must:

Stay alert and within 25 feet of the vehicle, with a clear view
Leave the area
Smoke
Run the engine at high RPM

Correct. During cargo-tank flammable-liquid loading or unloading, the driver must remain attentive and within 25 feet of the vehicle with an unobstructed view.

Question 13 of 20

When loading a vehicle with hazardous materials, you should:

Set the parking brake, chock the wheels, turn off the engine
Leave the engine running
Smoke if outside the cab
Skip the brake check

Correct. Set the parking brake, chock wheels of cargo tank vehicles, and shut off the engine before loading or unloading flammables.

Question 14 of 20

Bulk packaging of certain corrosives requires:

No special markings
Display of the proper shipping name on each side and the four-digit ID number on each side and end
Only one placard
Painted red

Correct. Bulk packaging of corrosives, like other hazmat, requires shipping name on the sides and ID-number marking on each side and end.

Question 15 of 20

You may use a flame to check for hazmat leaks:

When you have a respirator
Never — never use any flame near hazmat
Only at night
Only with permission

Correct. Never use a flame to check anything near hazmat. Use a flashlight or other intrinsically safe light.

Question 16 of 20

When you stop at a railroad crossing in a placarded hazmat vehicle, you must stop:

On the tracks
Between 15 and 50 feet from the nearest rail
Anywhere
Only if a train is visible

Correct. Placarded hazmat vehicles must stop at every railroad crossing 15 to 50 feet from the nearest rail. Look and listen for trains.

Question 17 of 20

How many hazard classes are there?

Three
Five
Nine
Twelve

Correct. There are nine hazard classes: 1 explosives, 2 gases, 3 flammable liquids, 4 flammable solids, 5 oxidizers and organic peroxides, 6 toxic and infectious, 7 radioactive, 8 corrosive, 9 miscellaneous.

Question 18 of 20

Where can a hazmat-placarded vehicle never be parked?

On private property
Within 5 feet of the traveled portion of a roadway, except briefly for vehicle operation
Anywhere
At a truck stop

Correct. Never park within 5 feet of the traveled portion of a road. Avoid populated areas, near open fires, and near places where people congregate.

Question 19 of 20

Placards are required when:

Any amount of a Table 1 material is loaded, or 1,001+ lbs total of any combination of Table 2 materials
Any cargo is loaded
Only flammables are loaded
Only at the driver's discretion

Correct. Table 1 materials always require placards (any amount). Table 2 materials require placards when 1,001 pounds or more of any combination is loaded.

Question 20 of 20

A driver of a placarded hazmat vehicle approaching a tunnel that prohibits hazmat must:

Use a designated alternate route
Drive through quickly
Cover the placards
Go around the prohibition sign

Correct. Many tunnels prohibit certain placarded vehicles. Use the designated alternate route. Bypassing the prohibition is a serious violation.

About the Hawaii Hazmat exam

Most states administer 30 Hazmat questions and require 80% to pass. The exam covers hazard classes, the shipping paper, placards and labels, loading and unloading, driving and parking rules, emergency response, and the Emergency Response Guidebook (ERG).

The Hawaii Driver License Office follows the federal CDL standards established by FMCSA. To earn the Hazmat credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Hazmat question bank or browse all Hawaii CDL practice tests.