Colorado Tanker CDL Practice Test

This is a free 20-question practice test for the Tanker portion of the Colorado Commercial Driver's License knowledge exam. Questions are pulled from a pool of 50 drawn from the AAMVA CDL Manual, which is the source document the Colorado Division of Motor Vehicles uses to write its actual exam.

How it works: Click an answer. The correct choice highlights in green, and you'll see a short explanation. Aim for 85% or better before you sit for the real test in Colorado.

Question 1 of 20

Tanker pre-trip should specifically check:

Tank shell, intake/discharge/cut-off valves, manhole covers, venting devices, and pressure-relief equipment
Only the tires
Only the engine
Only the placards

Correct. In addition to standard pre-trip, inspect the tank shell, all valves, manhole covers, vents, and pressure-relief devices.

Question 2 of 20

A loaded tanker on a curve is most likely to:

Roll over because surge plus high CG amplifies side forces
Skid in a straight line
Brake faster
Steer easier

Correct. Side surge plus high CG creates a tipping moment well above what a flat-bed of equal weight produces. Speed reduction in advance is the only safe answer.

Question 3 of 20

Pressure relief devices on cargo tanks are designed to:

Open if pressure inside exceeds safe limits, releasing product or vapor before the tank ruptures
Increase pressure
Be tightened down
Stay closed at all times

Correct. Pressure relief valves open at a set pressure to prevent tank rupture. Tampering with them is illegal and dangerous.

Question 4 of 20

Compartmented tanks have:

Liquid-tight bulkheads dividing the tank into separate sections
No divisions
Smooth interior
Only baffles

Correct. Compartmented tanks have liquid-tight bulkheads. Each compartment is loaded separately, allowing different products in one trailer.

Question 5 of 20

A tanker with a high center of gravity is most prone to rollover during:

Straight-line driving
Tight curves, evasive maneuvers, and exit ramps
Backing
Stopping

Correct. High center of gravity makes tankers roll on tight curves, sudden lane changes, and exit ramps. Slow well in advance.

Question 6 of 20

When you drive a tanker on slippery roads, you should:

Drive faster
Reduce speed substantially and increase following distance
Use only the trailer brake
Maintain normal speed

Correct. Reduce speed by at least one-third on wet roads, by half on snow. Liquid loads make recovery from a skid much harder.

Question 7 of 20

Outage refers to:

Empty space left at the top of a tank to allow liquid expansion
The brake-out system
A power failure
A driver shortage

Correct. Outage is the empty space left at the top of a tank to allow liquid to expand as it warms. Different liquids require different outage percentages.

Question 8 of 20

A loaded tanker traveling 10 mph above the safe curve speed has a:

Lower rollover risk
Significantly higher rollover risk because rollover threshold scales with speed squared
Same risk
Better handling

Correct. Centripetal force scales with speed squared. Just 10 mph over safe speed can take you past the rollover threshold of a loaded tanker.

Question 9 of 20

When driving with a load that has a low specific gravity (e.g., gasoline) versus high (e.g., asphalt), you should:

Drive the same
Adjust for the differences in surge dynamics, weight distribution, and braking
Skip braking
Run hot

Correct. Different products have different densities, surge characteristics, and weight distributions. Adjust speed and braking for the load.

Question 10 of 20

Liquid in a partially filled tank causes:

No special concern
Surge — the load slosh that affects vehicle handling
Better fuel economy
Improved braking

Correct. Surge is the side-to-side or front-to-back movement of liquid in a partially filled tank — it can throw the rig forward, pull it sideways, and significantly affect handling.

Question 11 of 20

Tankers should be driven with:

Less following distance
More following distance and gentler control inputs than a dry van
The same as a car
Higher speeds

Correct. Tankers stop slower and roll easier. Increase following distance and use gentler steering and braking inputs.

Question 12 of 20

Cargo tanks must be inspected and tested:

Periodically per CFR requirements; intervals depend on tank specification (MC-306, MC-307, MC-312, DOT-406, etc.)
Once a decade
Never
Only when leaks appear

Correct. Cargo tanks have specific inspection and test schedules based on their DOT specification (visual, leakage, internal, pressure, and thickness tests).

Question 13 of 20

When braking a partially filled smooth-bore tank, you should:

Brake hard at the last minute
Brake gently and start braking earlier than usual to compensate for surge
Use only the trailer hand valve
Pump the brakes

Correct. In smooth-bore tanks, surge is severe. Brake gently and earlier than you would in a dry-van trailer to avoid being pushed forward.

Question 14 of 20

When the surge in a tanker pushes the rig forward at a stop, you may:

Brake harder
Be pushed past the intended stopping point
Skid backward
Have no effect

Correct. Forward surge can push the entire rig forward — past stop lines, into intersections, into the vehicle ahead. Plan your stops with extra distance.

Question 15 of 20

When unloading product from a cargo tank, you should:

Verify the receiving container can hold the load, bond and ground, control the flow rate, and remain within 25 feet for flammables
Walk away
Maximize flow rate
Smoke nearby

Correct. Pre-check receiving container, bond and ground, control flow rate to prevent splash and spill, and remain attentive for flammable liquids.

Question 16 of 20

Side-to-side surge is most likely to cause:

Improved fuel economy
Rollover, especially on curves and in evasive maneuvers
No effect
Better braking

Correct. Side-to-side surge can amplify side-loading forces, contributing to rollover on curves and exit ramps.

Question 17 of 20

When loading a cargo tank with flammable liquid, the driver must:

Stay alert, within 25 feet, with a clear view of the tank, and ready to handle emergencies
Leave for lunch
Smoke
Run the engine at high RPM

Correct. Federal rule: driver remains within 25 feet, alert, with a clear view, ready to act in case of overflow or emergency.

Question 18 of 20

A heavy liquid load with a baffled tank may still surge:

Front-to-back, despite the baffles
Not at all
Less than smooth-bore but baffles do not stop side-to-side surge
None of the above

Correct. Baffles reduce front-to-back surge but do not affect side-to-side surge — bulkheads are typically transverse, not longitudinal.

Question 19 of 20

When backing a tanker, you should:

Move slowly and watch for the high mounted lights and clearance, since the tank shape may affect visibility
Move quickly
Use only the trailer brake
Skip the helper

Correct. Tankers can have unusual mirror angles and rear visibility. Use a helper, move slowly, and watch for tank-mount lights and overhead clearance.

Question 20 of 20

On a wet road, a tanker should:

Maintain normal speed
Reduce speed by about one-third
Drive faster
Use only the trailer brake

Correct. On wet pavement, reduce speed by about one-third. On snow, by about one-half. Tankers are less forgiving than dry vans on slippery roads.

About the Colorado Tanker exam

Most states administer 20 Tanker questions and require 80% to pass. Topics include the unique handling of liquid loads, surge effects, baffles vs. smooth-bore, outage and expansion, inspection of the cargo tank, and emergency procedures.

The Colorado Division of Motor Vehicles follows the federal CDL standards established by FMCSA. To earn the Tanker credential, you must answer at least 80% of the questions correctly. Many candidates score lower the first time because the test pulls from a large pool — refreshing this page will give you a different mix of questions, drawn from the same authoritative source.

Want more practice? Try the full Tanker question bank or browse all Colorado CDL practice tests.